<M/T-Vehicles without AS&G system>, <M/T-Vehicles with AS&G system>, <A/T>| Items |
Trouble symptom |
Inspection procedure No. |
|
| Communication with M.U.T.-III |
Communication with engine-ECU is not possible |
1 |
|
| Engine warning lamp |
The engine warning lamp does not illuminate right after the ignition switch is turned to the "ON" position |
2 |
|
| The engine warning lamp remains illuminating and never goes out |
3 |
||
| Starting |
Starter impossible (Starter not operative) |
The starter not operative |
4 |
| Starting impossible (Starter operative but no initial combustion) |
The starter is operative and cranks the engine, but none of initial combustion is in the cylinders and the engine is not started. |
5 |
|
| Improper starting (Long time to start) |
It is long cranking to start the engine. |
6 |
|
| Improper idling |
The proper idling speed is not satisfied. |
7 |
|
| Engine stalls |
The engine stalls when decelerating |
The engine stalls at the deceleration. |
8 |
| Driving |
Poor acceleration |
The engine cannot obtain the acceleration corresponding to the degree of throttle opening although the engine is smooth at the constant speed. |
9 |
| A large amount of fuel consumption |
Compared with before, the fuel consumption is dramatically increased. |
10 |
|
| Knocking, Abnormal noise |
Knocking |
Sharp sound like a hammer striking on the cylinder walls during the driving can be heard and wrongly affects the driving. |
11 |
| Abnormal noise |
Abnormal noise during the engine operation. (It is presumed that this is caused by malfunction over the wide range.) |
||
| Exhaust gas |
White smoke |
Exhaust gases are extraordinarily white. |
12 |
| Black smoke, state of exhaust gas purification deteriorated |
The exhaust gases are extraordinarily black. The state of the exhaust gas purification is deteriorated. |
13 |
|
| Charging performance |
Battery rundown |
The battery is soon rundown or the charging ability of battery is small. |
14 |
| Cooling performance |
Overheating |
The temperature of engine cooling water is extremely high. |
15 |
| Inspection procedure No. |
Trouble symptom |
Reference page |
| 1 |
Communication with engine-ECU is not possible |
|
| 2 |
The engine warning lamp does not illuminate right after the ignition switch is turned to the "ON" position |
|
| 3 |
The engine warning lamp remains illuminating and never goes out |
|
| 4 |
Starter impossible (Starter not operative) |
<M/T-Vehicles without AS&G system>, <M/T-Vehicles with AS&G system>, <A/T> |
| 5 |
Starting impossible (Starter operative but no initial combustion) |
|
| 6 |
Improper starting (Long time to start) |
|
| 7 |
Improper idling |
|
| 8 |
The engine stalls when decelerating |
|
| 9 |
Poor acceleration |
|
| 10 |
A large amount of fuel consumption |
|
| 11 |
Knocking, Abnormal noise |
|
| 12 |
White smoke |
|
| 13 |
Black smoke, state of exhaust gas purification deteriorated |
|
| 14 |
Battery rundown |
|
| 15 |
Overheating |
|
| 16 |
Engine-ECU power supply system |
|
| 17 |
Engine-ECU battery back-up system |
|
| 18 |
A/C compressor relay system |
|
| 19 |
Fuel pump system |
|
| 20 |
Engine oil pressure switch system |
|
| 21 |
Water level switch system |
|